AC Evaporator Repair | Mel's Garage in Watertown

MEL'S GARAGE > The Best Auto Repair And Maintenance Services > AC REPAIR > REPAIR YOUR CAR'S AC EVAPORATOR

Moisture is the enemy of your car's air conditioning system. The evaporator is your AC system's front line of defense against unwanted moisture. Replacing a car AC evaporator is not an easy job and should only be attempted by the pro mechanics at Mel's Garage in Watertown.

Replacing the entire evaporator assembly will save time and money down the road. Accessing your car's AC evaporator is easy because it is mounted inside the cabin of your vehicle. In fact, you can access your evaporator through your car's glove box. However, the lines going to and from the evaporator run throughout your air conditioning system and replacing them requires the disassembly of the engine bay.

Trust Mel's Garage in Watertown To Replace Your Car's Evaporator

Get AC unit full seal testing
Identify and repair internal corrosion issues.
Find troublesome micro cracks and leaks in the evaporator core
Pressurize and calibrate the AC system to manufacture standards

Monday	7:00AM - 5:00PM
Tuesday	7:00AM - 5:00PM
Wednesday	7:00AM - 5:00PM
Thursday	7:00AM - 5:00PM
Friday	7:00AM - 4:00PM
Saturday	Closed
Sunday	Closed
Sat by appointment

Visit Our Shop

We have friendly staff who will take care of you

Address:
602 Union St
Watertown, WI 53098

Get Directions
Have Questions?

We're here to help you!
920-261-1848

Send A Message

Vehicle Tips

According to recent studies, 5 percent of all motor vehicle fatalities are clearly caused by automobile maintenance neglect.
Vehicle Tips

The cooling system should be completely flushed and refilled about every 24 months. The level, condition, and concentration of coolant should be checked. (A 50/50 mix of anti-freeze and water is usually recommended.)
Vehicle Tips

Never remove the radiator cap until the engine has thoroughly cooled. The tightness and condition of drive belts, clamps and hoses should be checked by a pro.
Vehicle Tips

Change your oil and oil filter as specified in your manual, or more often (every 3,000 miles) if you make frequent short jaunts, extended trips with lots of luggage or tow a trailer.
Vehicle Tips

Replace other filters (air, fuel, PCV, etc.) as recommended, or more often in dusty conditions. Get engine drivability problems (hard stops, rough idling, stalling, diminished power, etc.) corrected at a good shop.
Vehicle Tips

A dirty windshield causes eye fatigue and can pose a safety hazard. Replace worn blades and get plenty of windshield washer solvent.
Vehicle Tips

Have your tires rotated about every 5,000 miles. Check tire pressures once a month; let the tires cool down first. Don't forget your spare and be sure your jack is in good condition.
Vehicle Tips

Check your owner's manual to find out what fuel octane rating your car's engine needs then buy it.
Vehicle Tips

Keep your tires inflated to the proper levels. Under-inflated tires make it harder for your car to move down the road, which means your engine uses more fuel to maintain speed.
Vehicle Tips

Lighten the load. Heavier vehicles use more fuel, so clean out unnecessary weight in the passenger compartment or trunk before you hit the road.
Vehicle Tips

Use the A/C sparingly. The air conditioner puts extra load on the engine forcing more fuel to be used.
Vehicle Tips

Keep your windows closed. Wide-open windows, especially at highway speeds, increase aerodynamic drag and the result is up to a 10% decrease in fuel economy.
Vehicle Tips

Avoid long idling. If you anticipate being stopped for more than one minute, shut off the car. Contrary to popular belief, restarting the car uses less fuel than letting it idle.
Vehicle Tips

Stay within posted speed limits. The faster you drive, the more fuel you use. For example, driving at 65 miles per hour (mph) rather than 55 mph, increases fuel consumption by 20 percent.
Vehicle Tips

Use cruise control. Using cruise control on highway trips can help you maintain a constant speed and, in most cases, reduce your fuel consumption.
Vehicle Tips

Keep your engine tuned. A fouled spark plug or plugged/restricted fuel injector can reduce fuel efficiency as much as 30 percent.
Vehicle Tips

Inspect the engine's belts regularly. Look for cracks or missing sections or segments. Worn belts will affect the engine performance.
Vehicle Tips

Have the fuel filter changed every 10,000 miles to prevent rust, dirt and other impurities from entering the fuel system.
Vehicle Tips

Change the transmission fluid and filter every 15,000 to 18,000 miles. This will protect the precision-crafted components of the transmission/transaxle.
Vehicle Tips

Inspect the suspension system regularly. This will extend the life of the vehicle's tires.

What our clients say about us?

Reviews and comments from our satisfied customers

Brakes, near Watertown, Wisconsin

We have trusted Mel's Garage for decades. Many garages will give you a long list of mystery repairs you need, aside from the work you requested. Tim and Cory would never do this. If you are looking for ethical mechanics who will do the work well and at a fair price, you have found your garage in Mel's. Great service, great mechanics.

Pam and Dan Martin, 10/06/2023
Mel's Garage was great to work with throughout a complicated mechanical problem on my car. Cory and his dad kept me advised of the status of the repair. Professionalism is exhibited during the entire auto repair process. Thank you and the entire team for superb service.

Dave J.
A little garage hidden away on a side street. But, tremendous customer service. We have used them for years, and they are very honest guys, with integrity. Very knowledgeable and fair.

Deborah P.
They were fast and so friendly. They ended up having exactly what I needed when I went in for a quote. They had me fixed up in about an hour. They guys were so friendly and courteous. Will definitely go back!

Kayla G.
Cory and Tim are great! They explain the issues more clearly than anyone else I have ever worked with and present options on how to address issues. Great to find a mechanic that can make things understandable. I drive 30 miles passing dozens of mechanics just to use Mel's Garage.

James M.
The mechanics are awesome. They don't upsell and they are honest about parts that need replacement and parts that can keep going for several months. They explain things after they fix them and charge a fair price. The only downside is the space. Because of their reputation, they are always full, but they don't have any parking space. So you need to park on the street, and that can be several blocks away when it's crowded. Don't let that stop you though, support this garage!

Josh H.